It is currently Mon Jul 24, 2017 8:35 pm

All times are UTC + 10 hours




Post new topic Reply to topic  [ 6 posts ] 
Author Message
 Post subject: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Wed Jul 12, 2017 11:46 am 
Offline

Joined: Wed Aug 31, 2016 3:54 pm
Posts: 4
Location: New Zealand
Hi gang,

We are in New Zealand. We have a 1986 Swift 1.3, 3 door manual with a G13A. The headgasket was replaced about 12,000km ago by my son, who is a competent mechanic. The car has done 192,000km.

Recently, it has started dropping down to three cylinders - maybe fewer - whilst being driven. Sometimes 5 minutes after starting, sometimes 25 minutes - sometimes it doesn't happen at all.

Each time, my daughter (who is the only driver) says that stopping the engine and restarting it, immediately resets the engine back to normal for another 5+ minutes.

I have changed the plugs. The old ones looked identical to each other.

I have changed the leads for a new set.

I have changed the distributor cap.

I have changed the coil.

I have NOT changed the rotor arm.

I have NOT changed the distributor - which has an electronic pickup.

Any ideas folk, other than change the dizzy?

I'm not convinced that it drops only one cylinder. The plugs don't seem to show that. And it hasn't done this fault with me in the car. I'm wondering if it's just dropping LOTS of sparks when it happens, and all cylinders suffer equally.

I'm sure that it's on the electrical side, because of it going away when the engine is turned off/on.

Any thoughts on further fault-finding, folks?

Adrian


Top
 Profile  
 
 Post subject: Re: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Thu Jul 13, 2017 8:56 am 
Offline
Moderator
User avatar

Joined: Mon Aug 25, 2003 12:00 am
Posts: 17497
Location: ACT
The issue could be fuel-related. Maybe an issue with the pump or fuel cut solenoid?

_________________
Suzuki MightyBoy - Three pots and a snail.


Top
 Profile  
 
 Post subject: Re: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Fri Jul 14, 2017 11:16 am 
Offline

Joined: Wed Aug 31, 2016 3:54 pm
Posts: 4
Location: New Zealand
Thanks for the idea! I hadn't thought about fuel delivery. I'll investigate.

Cheers!


Top
 Profile  
 
 Post subject: Re: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Fri Jul 14, 2017 5:22 pm 
Offline

Joined: Mon Aug 25, 2003 12:00 am
Posts: 1512
Location: Londoninium
Ignition module in the distributor could be your culprit. Mine suffered the same symptoms at about the same distance travelled. Its the Crescent shaped electrical bit in the distributor. Mitsubishi part. Try and find a mitshibishi part not a Suzuki part as at the time Suzuki wanted $400 mitsibishi wanted less than 100. Aftermarket may be available today. The original part is a Mitsubishi part.
Change rotor arm at same time.
Hope that helps.
GTP


Top
 Profile  
 
 Post subject: Re: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Sun Jul 16, 2017 4:54 pm 
Offline

Joined: Wed Aug 31, 2016 3:54 pm
Posts: 4
Location: New Zealand
Thanks GTP - you're actually the second person to suggest that to me, today - so I'm inclined to think it's likely. I'll follow up.

Cheers!


Top
 Profile  
 
 Post subject: Re: Intermittant misfire - 1986 Swift G13A (carb)
PostPosted: Mon Jul 17, 2017 9:45 pm 
Offline

Joined: Mon Oct 12, 2015 11:30 am
Posts: 56
Location: Wellington
The ignition module is the only item in the ignition system that you have not replaced, otherwise I would have suggested the other items you have replaced already.

Mine did similar, it was the frost plug on top of the head that was leaking coolant down into the spark plug chamber causing it to short out. But mine is twin cam efi, so you probably would not have that issue.

As mentioned, fuel delivery, fuel pump (sock too), filter, lack of fuel with a sticky float in the carb or something funny? I'm not too flash with carb knowledge....

Also, props on writing a detailed post. Much easier when you have all the info!
Make sure to post back here when fixed, we love to hear the results :D


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 6 posts ] 

All times are UTC + 10 hours


Who is online

Users browsing this forum: No registered users and 6 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Search for:
Jump to:  
Powered by phpBB © phpBB Group